PT. TRIMITRA BATERAI PRAKASA 

Charging

Charging Service Maintenace MSDS

Home Up

Battery Charging Guide
12 - Volt Batteries Recomended Charging Rate and Time from a Fully Discharge Condition
(ie.Flat,Discharged). Fast Recharging is not Recomended
Capacity Battery
Slow Charge
Fast Charge
50 AH or Less
16 hrs @   3 Amps
2.5   hrs @ 20 Amps, or 1.5 hrs @ 30 Amps
Above 50 to 75 Ah
21 hrd @   4 Amps
3.75 hrs @ 20 Amps, or 1.5 hrs @ 50 Amps
Above 75 to 95 Ah
22 hrs @   5 Amps
5      hrs @ 20 Amps, or 2    hrs @ 50 Amps
Above 95 to 135 Ah
23 hrs @   6 Amps
7.5   hrs @ 20 Amps, or 3    hrs @ 50 Amps
Above 135 Ah
24 hrs @ 10 Amps
6      hrs @ 40 Amps, or 4    hrs @ 60 Amps
Check the specification page for the capacity 20 hr
Vehicle Jump Starting
Warning : Modern vehicle with electronicmanagement system should not be jump started without "protected" jump starter leads and it is necessary to refer to owner's handbook for jump starting procedures for such vehicles.
Check that vehicle have same terminal earthed. If not, refer to manufacturers instructions.
Check that cables are not frayed or damaged
Carry out following steps in sequence :
This Hook-Up For Negative Earthed Vehicles
Charge01.jpg (5946 bytes)
Vehicle Jump starting procedure is as follow and should be followed care fully :
1. Check batteries are the same voltage
2. Turn off  all electrical loads, check vehicles are not
    touching and are in park or neutral
1. On  negative  grounded  system,  connect  both   ends  of  one
    cable to positive (+) terminal of both batteries
2. Connect  one  end  of  other  cable to negative  (-)  terminal  of
    booster battery
3. Connect other cable away from battery, to engine block or car
    frame of vehicle to started
4. Make  sure  cablesare  away  from  fan  blades and other moving
    vehicle parts.
5. Start engine of booster car.
6. Attempt to start engine of vehicle with discharged battery
7. If  vehicle  does  not  start  within  30   seconds,  call  an  auto
   electrician.
8. After   starting,   remove   cables    in  reverse  order,  starting
    with  one connected to engine block or car frame
 

Send mail to hoisiong@trimitra-baterai.co.id with questions or comments about this web site.
Last modified: July 12, 2010